Manitowoc Ice Bin Drain Installation

My church recently purchased an air cooled under the counter manitowoc ice machine.

Manitowoc ice bin drain installation.

Drain pump warning pumps waste water from ice machine to drain. Page 12 run separate bin and water cooled condenser drain important lines. In the cabinet slot where it is going to be installed on the far end of the kitchen with its back against an exterior wall consisting of sheet rock insulation metal siding we do have a water hookup available but do not have any drain to accommodate the gravity drain on the back of the machine for ice. Bin drain tube.

Couple small services and ice machine install with extra manitowoc features. Installation instructions general the location must allow enough clearance for water drain and electrical connections at the rear of the ice call manitowoc foodservice at 800 235 9698 for the machine. Pump outlet tube 13 50 b. Every commercial ice machine will require a drain in order to empty purged and melt water.

Connect wires 41 and 42 to the drain pump and connect. A customer called me out to take a look at her ice machine at a convenient store today the drain line for the ice machine is dumping out into the grass area but before that its leaking on the sidewalk for which the health inspector wrote her up on water on the sidewalk i looked in the store for a floor drain to pipe as an indirect waste by code but there wasn t one to be found right. The easiest way to do this is with a floor drain but if that is not an option for your location you will need a drain pump. Manitowoc ice machine installation checklist february 14 2014 0 comments after purchasing a manitowoc ice maker installation needs to be performed by a trained service professional.

Place two pieces of tape on the bottom of the drain pump. If you are installing a manitowoc water filter vent the ice machine drain. Part number 000014141 rev 07 2 20 indigo nxt ice machines installation operation and maintenance manual original document caution read this instruction before operating this equipment. However if you feel comfortable making all the electrical and plumbing connections yourself there are a few items that you will want to make sure are covered.

Preassemble tubes on drain pump. Some commercial ice machines can be ordered with built in drain pumps. Name of a local company capable of installation and start up services. Do not vent the system refer to the installation instructions condenser drain on water cooled models.

Insulate them to prevent condensation. Vent tube 26 0 c.